Home |
Search |
Today's Posts |
#1
|
|||
|
|||
Car Battery Tips
Top Ten Starting Battery Tips
1. Wear glasses when working with a battery, because it might explode. 2. Keep your non-sealed battery properly filled with distilled water and the top clean. The plates must be covered at all times. 3. To prevent permanent sulfation when not in use and especially in hot weather, keep your battery continuously connected to a "smart" or maintenance charger or recharge your battery at least one per week. Cheap unregulated "trickle" chargers will kill your battery. 4. In hot climates, keep your battery as cool as possible and non-sealed Low Maintenance or sealed AGM batteries are recommended. 5. When buying a replacement battery, be sure it matches your charging system & Cold Cranking Amps (CCA) requirements, physically fits, and is fresh. 6. Keep the battery cable mating surfaces and terminals free from corrosion. 7. Avoid a deep discharge of your battery. This could kill it. 8. For longer battery life, do not add acid or additives and keep your battery securely fastened. 9. Use chargers (or settings) that will recharge batteries over eight to ten hours. 10. Thaw out a frozen battery before attempting to jump or recharge it and always jump batteries positive-to-positive and negative-to-negative. For negative grounded electrical systems, the last negative connection should be to the frame or engine block away from the battery. For additional battery information, please go to http://www.batteryfaq.org. |
#2
|
|||
|
|||
Car Battery Tips
In article , "JohanWagener" wrote:
1. Wear glasses when working with a battery, because it might Hahaha. I wonder if this has ever happened? Its just so highly unlikely but stil they warn against it on any battery Remember the old saying, never look into the cells with a match. I know a fellow who did this. Wasn't me. I know a local junk yard that tests batteries by shorting them with a jumper. The bigger the spark, the better. I once acedently ran a big screwdriver across a big battery in the back of a military van. i jumped out before mounds of acid hit the ceiling. greg |
#3
|
|||
|
|||
Car Battery Tips
my neighbor was victim to a battery explosion while trying to jumpstart a
car. he was covered from the waist up with acid when the top of the battery burst open. luckily,he turned his head and avoided getting it in his eyes. "JohanWagener" wrote in message ... 1. Wear glasses when working with a battery, because it might Hahaha. I wonder if this has ever happened? Its just so highly unlikely but stil they warn against it on any battery |
#4
|
|||
|
|||
Car Battery Tips
I am an ex- toyota Mechanical engineer (quality control), NUMMI plant
Fremont CA. Some battery stories... A friends 96 tacoma had the battery explode... The top blew off and slammed the hood. It shot up and the + - terminals put huge dents on the hood. In the engineering audit lab a co-worker was removing the battery "-" clamp with a large wrench. Something happened, I guess he slipped, and the wrench bridged across the + and - posts. Sparks and smoke flew as he jumped back, when the smoke cleared a little, the wrench melted and welded itself across the terminals and was RED hot. He used channel lock pliars and tried to pull the wrench off the posts, but it was too hazardous. Flames broke out and the rubber/foam components in the engine caught fire. Fortunately in both these incident no one was hurt. Garrett Bill Darden wrote: Top Ten Starting Battery Tips 1. Wear glasses when working with a battery, because it might explode. 2. Keep your non-sealed battery properly filled with distilled water and the top clean. The plates must be covered at all times. 3. To prevent permanent sulfation when not in use and especially in hot weather, keep your battery continuously connected to a "smart" or maintenance charger or recharge your battery at least one per week. Cheap unregulated "trickle" chargers will kill your battery. 4. In hot climates, keep your battery as cool as possible and non-sealed Low Maintenance or sealed AGM batteries are recommended. 5. When buying a replacement battery, be sure it matches your charging system & Cold Cranking Amps (CCA) requirements, physically fits, and is fresh. 6. Keep the battery cable mating surfaces and terminals free from corrosion. 7. Avoid a deep discharge of your battery. This could kill it. 8. For longer battery life, do not add acid or additives and keep your battery securely fastened. 9. Use chargers (or settings) that will recharge batteries over eight to ten hours. 10. Thaw out a frozen battery before attempting to jump or recharge it and always jump batteries positive-to-positive and negative-to-negative. For negative grounded electrical systems, the last negative connection should be to the frame or engine block away from the battery. For additional battery information, please go to http://www.batteryfaq.org. |
#5
|
|||
|
|||
Car Battery Tips
In article ,
"JohanWagener" wrote: 1. Wear glasses when working with a battery, because it might Hahaha. I wonder if this has ever happened? Its just so highly unlikely but stil they warn against it on any battery Yes. Car batteries contain a mixture of air, oxygen, and hydrogen above the electrolyte. They can explode with enough force to spray acid if a plate breaks or shorts (a common failure mode) while you're working on it. |
Reply |
Thread Tools | |
Display Modes | |
|
|
Similar Threads | ||||
Thread | Forum | |||
Battery backup for Sony clock radio | General | |||
Grado SR-80 Comfort Tips | General | |||
Voltage drop on ignition | Car Audio |